Product ID:715 SPRAFLEX AEROSOL
MSDS Date:02/03/1994
FSC:6850
NIIN:00F036175
MSDS Number: BTVKK

A W CHESTERTON CO

225 FALLON ST
STONEHAM, MA 02180-2999
US

Emergency Phone: 617-438-7013

Info Phone: 617-438-7000

Cage: 71431

CHESTERTON A W CO

STONEHAM, MA 02180-9101 US

Telephone: 781-438-7000/800-535-5053

Cage: 71431

ISOPARAFFINIC HYDROCARBONS (NAPHTHA PETROLEUM),

CAS: 64742-48-9

Fraction By Weight: 15-25%

ASPHALT FUMES, ASPHALT, CUTBACK ASPHALT

CAS: 8052-42-4

RTECS: CI9900000

Fraction By Weight: 30-40%

ACGIH TLV: 5 MG/CUM

PROPANE

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 5-10%

OSHA PEL 1000 PPM

ACGIH TLV: SIMPLE ASPHYXIANT

ISOBUTANE, 2-METHYLPROPANE

CAS: 75-28-5

RTECS: TZ4300000

Fraction By Weight: 1-5%

OSHA PEL 1800 MG/CUM

ACGIH TLV: 1000 PPM

BUTANE, N-BUTANE

CAS: 106-97-8

RTECS: EJ4200000

Fraction By Weight: 5-10%

OSHA PEL 800 PPM

ACGIH TLV: 1900 MG/CUM

XYLENE, DIMETHYLBENZENE, XYLOL

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 1-5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION. INHALATION OF VAPOR
CONCENTRATIONS IN EXCESS OF 1000 PPM WILL CAUSE EYE & RESPIRATORY
TRACT IRRITATION & OTHER CNS EFFECTS. INJECTION INTO THE BODY W/O
IMMEDIATE MEDICAL TREATMENT MAY CAUSE LOSS OF AFFECTED PART OF THE
BODY. CHRONIC: PROLONGED/REPEATED SKIN CONTACT MAY DEFAT &
IRRITATE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DIZZINESS, HEADACHE, IRRITATION. PROPANE CAUSES
DIZZINESS AT 100,000 PPM.
Medical Cond Aggravated by Exposure:PRE-EXISTING DERMATITIS

First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, ADMINISTER
CPR. SKIN: WASH SKIN W/SOAP & WATER. EYES: FLUSH FOR 15 MINS
W/PLENTY OF WATER. INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IN ALL CASES.

Flash Point Method:CC
Flash Point:108F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM/WATER FOG.
Fire Fighting Procedures:COOL EXPOSED CONTAINERS W/WATER. WEAR SCBA.
Unusual Fire/Explosion Hazard:WATER MAY CAUSE FROTHING. PRESSURIZED
CONTAINERS WHEN HEATED ARE A POTENTIAL EXPLOSIVE HAZARD.

Spill Release Procedures:EVACUATE AREA. CONTAIN TO A SMALL AREA. FLUSH
AWAY FROM IGNITION SOURCES W/WATER. PICK UP W/ABSORBENT MATERIAL &
TRANSFER TO A SUITABLE CONTAINER FOR DISPOSAL. KEEP AWAY FROM
SEWERS, STREAMS & WATER W AYS.

Handling and Storage Precautions:DON'T STORE IN DIRECT SUNLIGHT/>120F.
Other Precautions:IF PRODUCT IS HEATED, USE ADEQUATE VENTILATION.

Respiratory Protection:NOT NORMALLY NEEDED IF PEL/TLV IS EXCEEDED, USE
APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:NO SPECIAL REQUIREMENTS. IF PEL/TLV IS EXCEEDED, PROVIDE
ADEQUATE VENTILATION.
Protective Gloves:CHEMICAL RESISTANT/NITRILE/RUBBER
Eye Protection:SAFETY GLASSES/GOGGLES
Other Protective Equipment:NONE
Supplemental Safety and Health

Boiling Pt:B.P. Text:280F
Vapor Density:>1
Evaporation Rate & Reference:(ETHER=1): >1
Percent Volatiles by Volume:35.4

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, LIQUID CHLORINE & CONCENTRATED OXYGEN.
Stability Condition to Avoid:OPEN FLAMES, RED HOT SURFACES & OTHER
IGNITION SOURCES.
Hazardous Decomposition Products:CO, ALDEHYDES & OTHER TOXIC FUMES.

Waste Disposal Methods:INCINERATE ABSORBED MATERIAL. DON'T INCINERATE
PRESSURIZED/SEALED CONTAINERS. LANDFILL SEALED CONTAINERS IN
APPROVED AREAS. DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGULATIONS.
UN1950.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.